Hybrid-Stages

Aus Prius Wiki

Version vom 30. Juli 2006, 11:20 Uhr

Quelle: http://priuschat.com/forums/kb.php?k=14&mode=article

Auf oben genannter Seite stehen die 4 Stages, die das Hybrid-System absolviert, vom Start bei S1 bis zum vollen Betrieb bei S4.

Der Text ist erstmal in Englisch, bis er Schritt für Schritt übersetzt ist.

S1

In Stage 1 ist der ICE kalt. Wenn der EV Modus nicht aktiviert ist, schaltet sich der ICE wenige Sekunden nach dem Starten des Hybrid-Systems ein. Bis der System nicht die Übergangstemperatur von S1 zu S2 erreicht hat, läuft der ICE durchgehend. Das ist auch der Grund für die unüblichen Anzeigen des Stromflusses oder auch gar keiner Strompfeile (rollen lassen) trotz laufemdem ICE bei niedriger Geschwindigkeit. Es wird keine Energie vom ICE gewonnen, aber er läuft.

Auffällig in Stage 1 ist auch, daß Batterie-Energie verwendet wird, um die Beschleunigung des ICE abzumildern. Der HSD versucht, möglichst keine Energie vom ICE zu verwenden, wenn es nicht zwingend nötig ist. EV-Mode kann in Stage 1 nicht eingeschaltet werden.

[In Stage 1 the ICE is cold. If not prevented by use of the EV switch, the ICE will start a few seconds after the car is powered On. Until the system reaches the S1/S2 transition temperature, the ICE will run continuously. This accounts for the anomalous observation of electric regeneration or no arrows (coasting) at the same time as a low instantaneous mpg reading. No power is being drawn from the ICE, but it is running. Also in Stage 1 you will notice that battery power is used for even mild acceleration. In Stage 1 the HSD prefers not to draw power from the ICE if it is not necessary. You cannot enter EV mode while in Stage 1.]

S2

Wenn die Systemtempeator 40° C erreicht hat geht der Computer in Stage 2. 'Leider erinnert sich der Autor nicht mehr an alle Details.' Jedenfalls geht der ICE aus, wenn er nicht gebraucht wird. Hält man den Wagen an, geht der ICE sofort aus - und sehr leise. Aber der Wagen geht nicht in den "Golf-Wagen-Modus" ins Stage 2, d.h. die Batterie kann geladen oder Energie entnommen werden, aber der ICE wird beim Fahren immer benutzt.

[When the system temperature reaches 40 degrees C. (104 F.) the computer goes to Stage 2 operation. The original Japanese poster gave more detail than I clearly remember, but it appears that in Stage 2 the ICE will shut off if it is not needed to provide power. At a stoplight, in S2, the ICE will stop immediately and fairly smoothly. However, the car will not go into golf-cart mode in Stage 2. It can draw power from the battery or it can recharge the battery, but will not use the battery without the ICE. I have not ascertained if you can enter EV mode from S2.]

S3

Wenn das System 73° C erreicht hat, geht der Computer in Stage 3a über. In 3a läuft der ICE ständig, bis der Wagen für 5 bis 10 Sekunden vollständig anhält. Verrückterweise streubt sich der ICE in S3a wesentlich mehr sich abzuschalten, als in S2 - und wenn er sich dann abschaltet, tut er das sehr unruhig, geradezu rau: man merkt, wie das ganze Auto rüttelt. Ist er aber dann aber bei einem vollständigen Halt in S3a endlich ausgegangen, ist man in Stage 4.

Ist der Wagen in S3a und man fährt schneller als 34 MPH (~ 54 km/h) ohne einen vollständigen Halt für 5 bis 10 Sekunden vorher gehabt zu haben, geht das System in Stage 3b. S3b ist so ähnlich wie Stage 4, der einzige Unterschied ist, daß wenn man längsamer als 34 MPH fährt und die Bremsen betätigt, man wieder in S3a ist. EV-Mode kann in S3 aktiviert werden.

[When the system temperature reaches 73 C. (163.4 F.) the computer goes into Stage 3a. In S3a the ICE will not shut off unless you come to a full stop for 5 or 10 seconds. Paradoxically, it is more reluctant to shut off than it was in S2, and in S3a it shuts off very roughly. You will feel the car shudder. But once it does shut off at a full stop in S3a, it will then be in Stage 4 operation.

Once the car is in S3a, if you reach 34 mph without having come to a full stop for 5 or 10 seconds, the car will go into S3b operation. S3b is identical to Stage 4, except that if you slow down below 34 mph and apply the brakes, you will be back in S3a. In S3 you can engage EV mode providing that you meet all the conditions for EV mode.]

Anmerkungen des original Autors:

I have observed that at the full stop in S3a sometimes the ICE stops after 5 seconds, and other times runs for 10 seconds before stopping. I do not know what determines the difference. I have also observed more than one rough shut-down in a trip, suggesting to me that perhaps the ICE may sometimes stop roughly in S2, and may not stop immediately when you let off the accelerator in S2. I repeat that I do not clearly understand Stage 2 operation.

Coming to a full stop while in EV mode does not seem to trigger S4. You must be in normal mode when you stop in order to enter S4 operation.

S4

Stage 4 is normal, full hybrid operation. The Prius is most efficient in S4. The car will go into golf-cart mode at the computer’s discretion. You can encourage it to do so by lifting your foot off the accelerator pedal for a moment, and then pressing on the pedal very lightly. This is known as “feathering” the pedal. Feathering does not force the car into golf-cart mode, nor is it necessary for the car to go into golf-cart mode. It merely encourages the car to do so a little bit sooner than it would otherwise do on its own. The benefit of feathering the pedal is questionable, since the computer is deciding when it thinks Golf-Cart Mode is most desirable. Increasing the time spent in Golf-Cart Mode may only increase the efficiency losses involved in charging the battery and drawing power from it. On the other hand, encouraging Golf-Cart Mode when the SOC is very high may be useful, as it creates head room in the battery to accept charge wheen needed.

Above 42 mph the ICE must spin, and will generally provide power. It is possible for the ICE to spin without providing power to the car above 42 mph, and this has been observed. But since the ICE is more efficient at these higher speeds, Golf-Cart Mode above 42 mph (Super Golf-Cart Mode) is unusual. So the maximum speed in EV Mode is 34 mph, cutting out at a tiny fraction over 34 mph, and the maximum common speed in golf-cart mode is 42 mph. You can go faster in non-EV golf-cart mode than you can in EV mode.

Thanks to jfschultz for providing the transition temperatures given above. They were cited by a Japanese poster some time ago but I had forgotten them.

— Sidebar on using EV mode. The following is my personal speculation: —

EV Mode is inherently inefficient because not all the energy fed to the battery comes back out of it. Heat is generated when charging the battery and when drawing it down. However, there are situations when I believe EV mode is desirable:

Short trips: Because the car’s warm-up cycle burns extra gas to get the catalytic converter hot as quickly as possible to reduce emissions, if you have enough charge to complete a trip entirely in EV mode I believe you more than offset the efficiency losses mentioned above.

End of day: This is very speculative, but I believe that the system is reluctant to charge the battery if it is at or above 6 bars. Since the ICE will insist on running until it reaches Stage 4, more power will be produced than is needed to drive the car, and it is desirable that this energy be used to charge the battery. I believe that leaving the SOC at around 4 bars (or even 3) at the end of the day will provide the head room necessary to assure that the most energy possible produced during the inefficient warm-up cycle (Stages 1 through 3a) gets into the battery. Thus if your first trip of the following day will not be short enough to make entirely in EV Mode, I think it is a good idea to use EV at the end of the last drive of the day, if necessary, to leave the SOC at around 4 bars. You burn no gas during that last half-mile or so, and you leave head room in the battery for the next morning’s obligatory warm-up cycle.

Very slow driving: I sometimes observe very low instantaneous mpg at slow speeds even with a high SOC. And I never observe very good instantaneous mpg at slow speeds except in Golf-Cart Mode, when it’s at 99.9. I therefore believe that it’s always a good idea to use EV Mode at very slow speeds, such as parking lots or creep-and-stop traffic jams.

Showing off: Sometimes you just want to show off how quiet the car is. It may not be the most efficient thing for the circumstances, but it’s fun.

— End Sidebar —